Screenings for Patios in Nazareth, PA

Pennsylvania Rock Supply handles gravel and aggregate delivery in Nazareth, PA for two kinds of buyers: contractors who order on account and homeowners finishing a patio or drive on weekends. Both usually start with the same question about base. In Northampton County that answer is 2A modified, the crushed stone with the fines left in that locks up hard under a patio, a shed pad or a parking area.

Ground and Conditions in Nazareth

Nazareth sits in the Great Valley and Ridge and Valley ground zone, where folded bedrock leaves long sandstone ridges above valleys floored by shale or by limestone and dolomite that weathers to clay. That mix decides how a base behaves.

A base that is too thin or holding water shows itself fast here. Cold winters bring repeated freeze-thaw cycles that heave and crack a shallow layer, and the usual culprit is a base that never drained. Screening out the problem starts with clean stone at the bottom, not more fines on top.

Runoff off steep ridge slopes scours roadside ditches, culvert outlets and gravel drives, so water needs somewhere to go. In the limestone and dolomite valleys, runoff concentrated from roofs, gutters and drives can open sinkholes, which is one more reason to move water away from a patio edge instead of letting it pool.

Timing matters as much as material. Base, driveway and paver work runs from spring, once the ground has thawed and dried, into late fall, and base stone should not go down on frozen, soft or muddy ground. Frost depth in this area runs about 36 inches and is set by each municipality, so check with your code office before you plan footings or a deep base.

Materials for Nazareth Projects

The patio angle is where most of the questions land, because bedding and base are two different jobs. Under pavers and flatwork you want material that compacts firm and holds grade, and on top of the base you want a thin, even bedding layer that will not shift under foot traffic.

2A Modified is the standard Pennsylvania base stone and the one to order first. It is crushed stone with the fines left in, so it compacts hard and carries a patio, driveway or parking pad without pumping. Pennsylvania buyers sometimes ask for Crusher Run for the same job, and it works the same way as a compacting base with fines mixed in.

For the bedding layer itself, Screenings are the practical pick. Also called stone dust, they run under a quarter inch and pack firm, which is what you want under flagstone, pavers and walkway surfaces. Where a job wants tight joints or fine bedding, #89 Crushed Stone is the small washed option.

Drainage still has to go in before the bedding. 2B Stone is clean, washed crushed stone with no fines, so water moves through it instead of sitting against the house. French drains, drainage behind retaining walls and shed pads in wet spots all call for it. #57 Stone is the same size range that yards here call 2B, and it also works as concrete aggregate.

Sand rounds out a patio order. Washed Sand, also called concrete sand, is used for concrete, leveling and bedding under pavers and slabs, while Mason Sand covers brick and block mortar, paver joints and play sand. If you are raising grade before any of it goes down, Fill Dirt fills low spots and backfills, and Top Soil handles final grading and bed prep after the hardscape is finished.

Delivery to Nazareth and the Surrounding Area

You order online, and the first choice is quantity by the ton or by the yard. Both work, and the calculator on each product page does the conversion for you. Have your measurements ready before you start, then let the calculator size the load.

Bulk delivery means a dump truck backed to the site and the material placed where you want it dumped. Think about access before the truck arrives: width at the gate, overhead wires, and whether the driver can pull out loaded. A patio pour or paver install usually wants the stone dropped as close to the work as the truck can safely reach.

Pennsylvania Rock Supply delivers across Northampton County, including Bethlehem, Easton, Northampton, Hellertown and Bangor. Pick your delivery date at checkout and the material arrives ready to spread.

Questions Nazareth Buyers Ask

What gravel is best for a driveway in Nazareth?

For most drives here, 2A modified is the right base because the fines let it compact hard and hold up to freeze-thaw. Top it with driveway gravel if you want a fresh wearing surface. If the drive sits wet, put clean 2B stone underneath for drainage before the 2A modified goes down.

How much material will my project need?

Measure the area and the depth you plan to build, then enter those numbers into the calculator on the product page. It converts your figures into tons or yards so you can order the right amount. Ordering by the ton or the yard both work, and the calculator handles the math either way.

Order Screenings and Base Stone for Your Nazareth Project

Start with the calculator to size your load, then pick a delivery date that fits your schedule. Pennsylvania Rock Supply delivers 2A modified, screenings, sand and soil throughout Nazareth and Northampton County. Place your order online when your quantities are set and we will get the truck headed your way.